简介:
AB自流水平泥采用进口喷雾干粉树脂、特种水泥、精细骨料等共聚物组成。应用欧洲严格生产工艺和配方精制而成,与水混合后形成一种流动性强、高塑性的自流平地基材料。适用于所有铺地材料,广泛应用于民间及轻型商业建筑。
性能特点:
1.流动性能优质,自动精找平地面,可大大提高种铺地材料和使用寿命和装饰效果。
2.施工方便,硬化迅速,正常情况下24小时即可铺设各类地面材料。
3.优异的抗压,抗折强度。
4.加水混合后,无味、无毒、安全环保。
施工步骤:
1.地基表面必须洁净、永久性、干燥、强度大于C20,没有结构上的缺陷。
2.采用AB多功能界面剂(约2~6小时后)开始自流平施工。
3.将水6.5kg左右倒入适当容器,然后将一包AB自流平水泥缓慢倒入,边搅拌边倒入到均匀,无团浆料。将混合料倒出所施工区域,均匀铺开,用专用齿口刮板控制厚度。刚施工好的区域避免阳光直射和强风。
4.在自流平初凝前用消泡滚筒扎地面以排除混合时带来的空气。
注意事项:
1.理论涂布量,25kh可涂布8㎡(按2mm厚度计算),增加厚度则以此类推。
2.水、AB自流平比为约6.5kg(水):25kg(AB自流平)。
3.在0℃-40℃ 仓库中储存保持期为6个月。
4.本品在运输、储存中应防水、防潮。
5.施工温度为5℃-35,可施工时间:约20分钟。
Brief
Introduction:
AB
Self Leveling Concrete is made of imported spray dry powder resin, special
concrete and superfine aggregate by strict production technics and formula from
Europe. Mixed with water, it becomes a self leveling foundation level with
strong fluidity and high plasticity. Being applicable to all ground laying
materials, it is widely used in civil and light commercial buildings.
Features:
1.high-quality
fluidity, level the ground auto matically longer the service life of kinds of
ground laying materials with decorative effect.
2.easy
for construction, rapid hardening(kinds of floor materials can be laid after 24
hours normally)
3.high
pressure resistance and fold flexural resistance.
4.non-flavor,
non-toxic, safe and environmental after mixed with water.
Construction
steps:
1.The
ground should be clean, durable and dry with hardness higher than C20, Without
any crack.
2.Start
self leveling procedure after use the AB Multifunctional Interfacial
Agent(about 2 to 6 hours)
3.Pour
about 6.5kg water to a vessel, and a pack of AB Self Leveling Concrete as stir
to make them mix evenly. Pour the mixture to the construction parts meeded
evenly and control the thickness by sawtooth blade. Prevent the ground laid
from direct sunshine or strong wind.
4.Press
on the surface by bulb removing roller before stable condensation to remove
thered-undant air.
Notices:
1.Theoretical
Coating Weight:25kg for 8㎡(with thickness 2mm).
2.Ratio
of water and ABself leveling concrete:6.5kg water, 25kg concrete.
3.Quality
Guarantee Time:6 months in warehouse under 1~40℃.
4.Prevent
it from water and damp during transportation and storage.
5.Make construction under the temperatuer
between 5℃ to 35℃, Working time:about 20 minutes.